Secure Your Indiana Oversize Permits Today – Call Now! Indiana Phone no.# (630) 800 4551
Indiana Overweight & Oversize Trucking Permits for Single Trip, Fuel, Overhang and Annual Permits
Hire permit agency for your Indiana Oversize Permits and Overweight Permits Service Online for All States quickly! From Indiana Oversize Permit Login to Indiana Oversize Permit Cost, we make the procedure easier. Access DOR: IN DOT Oversize Permits and handle your DOR IN DOT Truck Permit requirements of Legal dimensions, applications, tire law, escort rules, cost, phone number, routine for State, Permit limits, escort requirements, operating times, restricted travel and Travel days with experienced assistance, resulting in rapid and efficient service. Streamline your permit applications today to ensure easy travel across state lines
Indiana Oversize permits validity, Indiana Legal Dimensions, Routine Permits requirements, Escort/Pilot car information & Indiana oversize rules and Regulation all your needs
Indiana Oversize Permits Validity: These permits are valid for Fifteen-days. Before entering with a heavy haul, it is necessary to secure permits.
Indiana Operating Time: Vehicles up to 110 feet in length, 10 feet in width, and 13 feet 6 inches in height, weighing no more than 200,000 pounds, are authorized to run continuously, 24 hours a day, seven days a week. Travel is allowed for those measuring more than 110 feet in length, 10 feet to 14 feet 4 inches wide, and up to 15 feet high from 30 minutes before sunrise to 30 minutes after sunset every day. Loads ranging from 14 feet 4 inches to 16 feet wide can travel Monday through Friday between an hour and a half before sunrise and an hour and a half after sunset. Loads larger than 16 feet in width, more than 15 feet in height, or weighing more than 200,000 pounds are normally allowed to move only between 8:30 AM and 3:30 PM, Monday through Friday, however exact requirements may differ. Overweight loads, while just overweight, may function 24 hours a day.
Indiana Travel Restriction: Travel is restricted on major holidays and holiday weekends.
Indiana Turnpike: Without a state authorization, the maximum allowable dimensions on toll roads are 12 feet wide, 14 feet 6 inches high, 65 feet long, and a total weight of 90,000 pounds. This restriction applies only to routes that include toll roads. Loads that exceed these dimensions require a state permission, as well as an additional $50 special permit cost. Any weight-related expenses are covered by the state permission. Loads greater than 10 feet must be moved only during daylight hours, although loads up to 12 feet wide are permitted to operate on weekends, save on recognized holidays. Toll costs are calculated depending on the number of axles and the distance traveled. Loads smaller than 12 feet wide can travel on the toll road between Portage’s Gate 21 and the Ohio state line for an estimated $30.00. The escort standards are consistent with those required for other divided roads in Indiana.
Indiana Oversize Permits
This permit is necessary when a vehicle exceeds the allowable weight restrictions imposed by an authority. It guarantees that the truck may move securely on roadways while causing no harm to infrastructure.
The permit is required for vehicles that exceed the standard-length limit. It enables the transportation of longer goods, such as huge beams or pipes, while maintaining their safety and legality.
Indiana Single trip permits are normally valid for one trip and is often necessary for trucks that do not have a regular IFTA (International fuel tax agreement) in place and IRP (International Registration Plan) registered. It enables the truck to drive through particular countries while remaining compliant with fuel tax requirements.
The permit is required when a load exceeds the rear or front of the vehicle. It guarantees that the overhanging weight is delivered securely, without endangering other road users.
A permit is necessary for vehicles that exceed the normal width limitations. It enables the transportation of larger loads, such as massive equipment or prefabricated constructions, while maintaining their safety and legality.
Indiana Legal Dimension
Indiana Legal Length: 53 feet for semi-trailer & for load including overhang with kingpin’s setting of 43 feet
Indiana Maximum Wide Load Without Permit: 8 feet 6 inches.
Indiana Legal Height: 13 feet 6 inches
Indiana Legal Weight Limit: Gross weight 80,000lbs
Single Axle 20,000lbs
Tandem Axles 34,000lbs
Tridem Axles 51,000lbs
Indiana Routine Permit Limit
Indiana maximum Length with permit: 110 feet
Indiana wide load with permit: 16 feet
Indiana Maximum Height allowed with permit: 15 feet.
Indiana Weight Limit: Single Axle 28,000lbs
Tandem Axle 48,000lbs
Tridem Axles 60,000lbs
5 Axle 108,000lbs Usually depends on axles
6 Axles 120,000lbs Usually depends on axles
Indiana Superload Permit: Loads surpassing these dimension / sizes or weight are treated as superload.
Important: Loads over 15 feet in height must be accompanied by a pre-approved signal contractor or utility bucket truck on any non-state routes. Loads over 17 feet in height require a route survey and a letter from the utility company if overhead lines need to be relocated.
Indiana Amber Light Permit Guidelines
Vehicles transporting oversize loads must be equipped with amber warning lights mounted on the roof to alert surrounding traffic.
Indiana Seasonal Weight Restrictions
While many states and provinces (particularly in Canada) enforce frost laws during colder months, Indiana does not impose specific seasonal load limits. However, some oversize permits issued by Indiana may include seasonal weight restrictions based on the type and nature of the load.
Oversize vehicles are not allowed to travel during hazardous weather conditions, when visibility is less than 500 feet, or during adverse road and traffic conditions. Travel is not allowed when wind speeds are higher than 25 mph.
Indiana Escort / Pilot Car Requirements and Information
Length-Based Requirements:
- Loads exceeding 110 feet require the use of one escort vehicle
- Loads over 130 feet, front and rear police escorts are mandatory
Width-Based Requirements:
- Loads over 12 feet 4 inches required one escort on all highways
- Between 14 feet 4 inches and 17 feet on divided highways required one escort; two escorts required on other roads
- Loads wider than 17 feet required front and rear police escorts are necessary on all road types
Height-Based Requirements:
- Loads over 14 feet 6 inches required one escort with a height pole
- Loads wider than 15 feet, must be accompanied by a utility bucket truck, except when operating on interstate highways.
Weight-Based Requirements:
- Loads exceeding 200,000 pounds GVW required two escort vehicles required.
Indiana Banners, Lighting & Flage Requirement
Any permitted load or vehicle must display “Oversize Load” signs that are clearly visible. Additionally, 18-inch square red or orange flags are required on each corner and at the widest points on both sides of the load. During transport, vehicles must travel with low-beam headlights illuminated at all times when carrying an oversize load.
Indiana Oversize Provisions Sheet Requirement
General Provisions of an Oversize/Overweight Vehicle Permit
In Indiana, a “required provision sheet” essentially refers to the specific requirements and restrictions outlined on an oversize/overweight (OSOW) permit issued by the Indiana Department of Revenue. This sheet details the conditions under which a vehicle can legally operate on Indiana roads when exceeding standard size and weight limitations.
Additional Information
Attachments such as blades, buckets, and similar equipment must be removed from the vehicle and hauled separately. No length exemptions are offered for beams or construction-related materials
Indiana Oversize/Overweight Fee Structure
Indiana Single Trip – Oversize Only
| Load Requirements | Permit Fee |
|---|---|
| Loads up to 95 ft length, 12 ft 4 in width, and within legal height limits. | $20.00 |
| Loads exceeding 95 ft up to 110 ft in length, 12 ft 4 in up to 16 ft in width, and 13 ft 6 in up to 15 ft in height. | $30.00 |
Indiana 90-Day & Annual Oversize Permits
$100.00
$405.00
$800.00
Combined Oversize & Overweight Permit Fees
| Gross Vehicle Weight | Additional Mileage Charge |
|---|---|
| 80,001 – 108,000 lbs | $0.35 per mile |
| 108,001 – 150,000 lbs | $0.60 per mile |
| 150,001 lbs and above | $1.00 per mile |
Additional Fees for High-GVW Loads
| Weight / Condition | Additional Fees |
|---|---|
| GVW over 120,000 lbs | $10.00 Executive Fee |
| GVW over 200,000 lbs | $10.00 Executive Fee + $25.00 Design & Review Fee + $10.00 per bridge crossed |
| Fewer than 10 bridges | Minimum bridge fee of $100.00 |
Special Weight Permit – Extra Heavy Overweight Trip
| Requirement | Fee |
|---|---|
| Special Weight Permit | $42.50 |
| Annual Company Registration | $25.00 per company |
Toll Road Gate Access
Frequently Ask Questions about Indiana Oversize Overweight Permits
Indiana oversize permits can be obtained online through our website comparetransportll.com or by calling us at (630) 800 4551
A permit is necessary for vehicles that surpass the standard legal dimensions or weight limits set by state regulations. Loads wider than 16 feet need a route survey; taller than 15 feet need utility or signal contractor; over 17 feet require a letter from utility companies. Travel time, escort, signage, and lighting rules also apply.
Yes. Oversize vehicles must follow speed limits, including reduced speed during bridge crossings and specific escort requirements. Some routes allow only 45 mph for bridge crossings. And any permitted vehicle or truck more than 85 feet long, 10 feet 6 inches wide or higher than legal height may not allowed to exceed 55 miles per hour
On divided highways, oversize vehicles must travel no more than 45 mph and stay centered between lanes with escorts blocking traffic. Same rule applies on undivided highways. After crossing, vehicles must continue moving and allow traffic to pass.
Indiana oversize permits can be obtained online through our website overweightpermit.com or by calling us at (630) 800 4551
Yes. Indiana issues 72-hour trip permits for out-of-state carriers and 5-day fuel permits under IFTA.
Yes. Vehicles exceeding legal dimensions must obtain Indiana oversize permits and meet escort, signage, and lighting requirements.
You can log in to manage your Indiana oversize permit through Our website overweightpermit.com
Single Trip Permit: Valid for 15 days
Quarterly Permit: Valid for 90 days
Annual Permit: Valid for 1 year
Special Weight Permit: Valid for one calendar day
80,000 pounds gross vehicle weight
Indiana does not enforce statewide seasonal weight restrictions, but specific oversize permits may include seasonal limitations. Travel is not allowed during hazardous weather or when visibility is below 500 feet or wind exceeds 25 mph.
Permits are required for vehicles exceeding legal size/weight. Requirements may include route surveys, escort vehicles, warning lights, signs, and travel time restrictions. Oversize loads must display "Oversize Load" signs and comply with axle/group weight limits.
13 feet 6 inches
Applications for Indiana oversize permits can be submitted online via our website comparetransportll.com or by calling us at (630) 800 4551
The price of an oversize permit in Indiana depends on the size of the load and how long the permit is valid.
Single Trip Permits:
Up to 95 feet long, 12 feet 4 inches wide, and/or 13 feet 6 inches tall: $20
Between 95 and 110 feet long, 12 feet 4 inches to 16 feet wide, and/or up to 15 feet tall: $30
More than 110 feet long, over 16 feet wide, and/or over 15 feet tall: $40
Quarterly and Annual Permits:
Quarterly Permit: $100
Annual Permit: $405
These permits apply to oversize loads that remain within 12 feet 4 inches in width, 13 feet 6 inches in height, and 110 feet in length.
The phone number for assistance is (630) 800 4551.
Yes, for certain dimensions. Vehicles under 110 ft long, 10 ft wide, and 13 feet 6 inches high can travel 24/7. Others have restricted hours based on size. Overweight-only loads may operate at all hours.
Length: Up to 53 feet
Width: Up to 8 feet 6 inches
Height: Up to 13 feet 6 inches
The maximum allowable gross vehicle weight is 80,000 pounds, though this may vary depending on axle placement and configuration.